Study of water permeation dynamics and anti-corrosion mechanism of graphene/zinc coatings

doi:10.1016/j.jallcom.2018.03.160

	Study of water permeation dynamics and anti-corrosion mechanism of graphene/zinc coatings
	Ding, Rui 1,2; Zheng, Yan 1; Yu, Haibin 1; Li, Weihua 2; Wang, Xiao 3; Gui, Taijiang 3
	2018-06-05
发表期刊	JOURNAL OF ALLOYS AND COMPOUNDS
ISSN	0925-8388
卷号	748 页码:481-495
通讯作者	Yu, Haibin(haibinyu@nimte.ac.cn)
摘要	In this paper, graphene/zinc-containing coatings were prepared and the mechanism of the action of graphene was discussed. The change in corrosion potential of the coating in artificial seawater was recorded in order to clarify the evolution in coating state. The electrochemical impedance spectroscopy (EIS) was measured and used to discuss the electrochemical structure of the coating in detail, and by the fitting of EIS together with cathodic protection current, the influence mechanism of graphene on the coating performance was discussed. SEM and micro-domain Raman spectroscopy were used to validate inferences about diffusion kinetics. EIS of dry coating and cathodic protection current were carried out to observe the cathodic protection. Depending on the coating state reflected by the corrosion potential, the coating process was divided into the stages of initial shielding, fluctuation, cathodic protection, shielding and failure. The electrochemical structures of the coatings and equivalent circuits at each stage were established. In the first two phases, the coatings undergone initial infiltration of corrosive media and activation of zinc particles. In the cathodic protection stage, the anode sacrificial reaction of zinc powder was the main process. During the shielding and failure stage, the steel substrate started to corrode. The EIS of the coatings with insufficient graphene shown the characteristic of capacitance of zinc corrosion product, since no coherent electron transport channels were formed. The characteristic of graphene that was first used was conductivity, which improved electrical contact between zinc particles as well as zinc and iron inferred from the EIS of dry coatings, and broken the block of non-conductive zinc corrosion products on the further anode sacrifices of zinc concluded from EIS of immersion test. This was advantageous for improving the utilization of zinc, increasing cathodic protection current and enhancing the protective properties of the coating. The dispersed and layered structure of the graphene sheet also improved the shielding performance of the coating, which was reflected in the initial shielding stage prior to cathodic protection relative to the non-graphene coatings and the reduced water diffusion coefficient in graphene-containing coatings. The tracking of the corrosive media using micro-Raman spectroscopy confirmed the enhanced barrier of the graphene coating. The process of water penetration into the coating was mainly Fick diffusion, which described by the equation of phi(z,t) = 1 + 4/pi Sigma(+infinity)(n=1)[(-1)(n) / (2n - 1)]cos[(z/L) (n - 1/2)pi]exp( - (Dt/L-2) (n - 1/2)(2)pi(2)). (C) 2018 Elsevier B.V. All rights reserved.
关键词	Graphene Zinc Coating Corrosion
DOI	10.1016/j.jallcom.2018.03.160
收录类别	SCI
语种	英语
资助项目	Ningbo major scientific and technological projects[Y60309DD03] ; National Science Fund for Distinguished Young Scholars[51525903] ; Qingdao National Laboratory for Marine Science and Technology[2017ASTCP-OS09] ; Qingdao Independent Innovation Special Project[16-7-1-2-ZDZXX] ; Ningbo major scientific and technological projects[Y60309DD03] ; National Science Fund for Distinguished Young Scholars[51525903] ; Qingdao national laboratory for marine science and technology[2017ASTCP-OS09] ; Qingdao Independent Innovation Special Project[16-7-1-2-ZDZXX]
WOS研究方向	Chemistry ; Materials Science ; Metallurgy & Metallurgical Engineering
WOS类目	Chemistry, Physical ; Materials Science, Multidisciplinary ; Metallurgy & Metallurgical Engineering
WOS记录号	WOS:000429838900060
出版者	ELSEVIER SCIENCE SA
引用统计	被引频次：89[WOS] [WOS记录] [WOS相关记录]
文献类型	期刊论文
条目标识符	http://ir.qdio.ac.cn/handle/337002/158466
专题	海洋环境腐蚀与生物污损重点实验室
通讯作者	Yu, Haibin
作者单位	1.Chinese Acad Sci, Ningbo Inst Mat Technol & Engn, Zhejiang Key Lab Marine Mat & Protect Technol, Key Lab Marine Mat & Related Technol, Ningbo 315201, Zhejiang, Peoples R China 2.Chinese Acad Sci, Inst Oceanol, Key Lab Marine Environm Corros & Biofouling, Qingdao 266071, Peoples R China 3.Marine Chem Res Inst, State Key Lab Marine Coatings, Qingdao 266071, Peoples R China
第一作者单位	中国科学院海洋研究所
推荐引用方式 GB/T 7714	Ding, Rui,Zheng, Yan,Yu, Haibin,et al. Study of water permeation dynamics and anti-corrosion mechanism of graphene/zinc coatings[J]. JOURNAL OF ALLOYS AND COMPOUNDS,2018,748:481-495.
APA	Ding, Rui,Zheng, Yan,Yu, Haibin,Li, Weihua,Wang, Xiao,&Gui, Taijiang.(2018).Study of water permeation dynamics and anti-corrosion mechanism of graphene/zinc coatings.JOURNAL OF ALLOYS AND COMPOUNDS,748,481-495.
MLA	Ding, Rui,et al."Study of water permeation dynamics and anti-corrosion mechanism of graphene/zinc coatings".JOURNAL OF ALLOYS AND COMPOUNDS 748(2018):481-495.

条目包含的文件
文件名称/大小	文献类型	版本类型	开放类型	使用许可
Study of water perme（7726KB）	期刊论文	出版稿	限制开放	CC BY-NC-SA	浏览